Airworthiness Directives 2004 - Revocation and Remaking - Boeing 737 Series Aeroplanes (Cth)
Airworthiness Directives 2004
I, DAVID ALAN VILLIERS, delegate of the Civil Aviation Safety
Authority, acting under subregulation 39.001 (1) of the Civil
Aviation Safety Regulations 1998:
(a) revoke the Airworthiness Directives mentioned in
Schedule 1; and
(b) make, as separate instruments, each Airworthiness
Directive mentioned in Schedule 1 and attached.
David Villiers
Delegate of the Civil Aviation Safety Authority
20 December 2004
Note: Each attached Airworthiness Directive is being re-made in exactly the
same form as appears in the latest published edition of the Directive.
Schedule 1 Revocation and Remaking of
Airworthiness Directives
Boeing 737 Series Aeroplanes
AD Name AD Number
Cockpit Side Window - F-N Window Post AD/B737/1 Amdt 2
Engine Fuel Supply - Leak Tests AD/B737/2
A.P.U. Generator, Feeder Wire Bundle - Inspection AD/B737/3
Side of Body Rib AD/B737/4 Amdt 1
Wing-To-Body Drag Angle AD/B737/5
Rear Pressure Bulkhead AD/B737/6 Amdt 1
Fuselage Frames Adjacent to Forward Airstair AD/B737/7
Evacuation Slide Compartment Latch Assembly AD/B737/8 Amdt 2
Horizontal Stabilizer - Centre Section Rear Spar AD/B737/9
Aft Lower Cargo Doorway Frame AD/B737/10 Amdt 1
Horizontal Stabilizer Centre Section - Rear Spar Upper Chord Attach Lugs AD/B737/11
Supplemental Structural Inspection Program AD/B737/12
Horizontal Stabilizer Centre Section AD/B737/13
Forward Lower Cargo Doorway Frame AD/B737/14
Fuel Boost Pump Bypass Valve AD/B737/15 Amdt 3
Engine Flameouts - Revised Operating Technique and Modifications AD/B737/16 Amdt 3
Aft Lavatory Dispenser Cavity Liner AD/B737/17
Take-Off Warning AD/B737/18 Amdt 1
Engine Overheat, Fire Detection and Fire Extinguishing Systems AD/B737/19
Engine Fire/Overheat Detection Module AD/B737/20 Amdt 2
Generator Control Unit (GCU) Filter Modules AD/B737/21
APU Fuel Drains AD/B737/22 Amdt 1
Forward Service Doorway Aft Frame AD/B737/23 Amdt 3
Forward Galley Doorway Upper Corners AD/B737/24
Forward Lavatory Drain System - CANCELLED AD/B737/25 Amdt 1
Forward Service Doorway - Aft Frame - CANCELLED AD/B737/26
TE Flap Track Support Fitting Attach Bolts AD/B737/27 Amdt 1
Flight Attendant Seats AD/B737/28 Amdt 1
Window Belt Skin Doubler AD/B737/29 Amdt 1
Engine Throttle Cable AD/B737/30 Amdt 2
Fuselage - Longitudinal Lap Joint Lower Skin at Left and Right Stringer 14 AD/B737/31
Configuration, Maintenance and Procedures Standard for Extended Range AD/B737/32 Amdt 3
Forward and Aft Cargo Compartments AD/B737/33
Forward Left Entry Door Fuselage Aft Frame Bottom Door Stop Fitting Bolts AD/B737/34
Engine Operation in Icing Conditions - CANCELLED AD/B737/35
Cabin Door Blowout Panels AD/B737/36
Fuselage Lap Joints BS259 to BS1016 AD/B737/37
Fuselage Lap Joints BS259 to BS1016 AD/B737/38
APU Fire Detector Element AD/B737/39
Structural Modification Program AD/B737/40
Forward Door Evacuation Slides AD/B737/41
Escape Slide Release Cable AD/B737/42
Nacelle Strut Firewall Seal AD/B737/43 Amdt 1
Fuel Tank Access Doors AD/B737/44
Takeoff Configuration Warning System AD/B737/45 Amdt 1
Engine Fire/Overheat Detection System AD/B737/46
Left Engine Fuel Feed Tube AD/B737/47
Rudder Trim AD/B737/48
Outboard Flaptrack Support Fitting Attach Bolts AD/B737/49
APU - EGT Overtemperature Condition AD/B737/50
Outboard Flap Forward Support Fitting Attach Bolts AD/B737/51
Corrosion Prevention and Control Program AD/B737/52 Amdt 2
Flight Attendant Seats AD/B737/53
Overhead Wire Bundle AD/B737/54 Amdt 1
APU Power Feeder Cable Bundle Chafing AD/B737/55
Engine Control Cable AD/B737/56
MLG Actuator Beam AD/B737/57 Amdt 2
Magnetic Standby Compass Liner AD/B737/58
Engine Fire Extinguishing System AD/B737/59
Crew Call Horn AD/B737/60
Main Deck Cargo Compartment AD/B737/61 Amdt 1
Main Fuel Tank Float Switch Electrical Harness AD/B737/62 Amdt 1
Stabilizer Trim Jackscrew Actuator AD/B737/63
Forward Door Escape Slide AD/B737/64 Amdt 1
Radio Control Panels AD/B737/65
Electrical Wiring Loom AD/B737/66 Amdt 1
Electrical Power Distribution P6 Load Control Centre Panel AD/B737/67
Sperry SP300 Autopilot Mode Control Panel AD/B737/68
Transro Single Flight Attendant Seat Pan AD/B737/69
Thrust Reverser - Auxiliary Slider Track Liner AD/B737/70
Brake Wear Limit AD/B737/71
Side of Body Floor Panel Inserts AD/B737/72
Cabin Overhead Stowage Bins AD/B737/73
Thrust Reverser Actuator Piston Seal AD/B737/74
Passenger Oxygen System AD/B737/75
Flight Control Cable Guards AD/B737/76
Pilot and Co-Pilot Seats AD/B737/77 Amdt 1
Evacuation Slide Valise AD/B737/78
Main Rudder Power Control Unit (PCU) AD/B737/79
Wing Leading Edge Panel AD/B737/80 Amdt 1
Thrust Reverser Control System Inspection and Modification AD/B737/81 Amdt 1
Thrust Reverser Sync-Lock System Test AD/B737/82 Amdt 2
Fuselage - Upper Deck Cargo Door - CANCELLED AD/B737/83
Main Rudder Power Control Unit (PCU) AD/B737/84
Fuel Actuator Shutoff Valve AD/B737/85
Body Station 344 to 360 Support Structure AD/B737/86
Fuselage Lap Joints, Lower Skins AD/B737/87 Amdt 2
Horizontal Stabiliser Trim Electric Actuator AD/B737/88
Main Deck Cargo Door - Existing Frame to Lower Sill Tie-Down AD/B737/89
Main Deck Cargo Door AD/B737/90 Amdt 2
Main Deck Cargo Door Hinge, Shim and Fairing AD/B737/91
Thrust Reverser Fan Cowl Firewall AD/B737/92
Galley Feeder Wiring AD/B737/93
Outboard Chords of BS 727 Frame and Stringer 18A AD/B737/94
Electrical/Electronics Equipment Bay Wire Chafing AD/B737/95
Fin Aft Terminal Support Fitting Bolts - CANCELLED AD/B737/96
Fwd Galley Service Door Lower Gate Hinge AD/B737/97
Krueger Flap Actuator Support Fitting AD/B737/98
Main Rudder Power Control Unit (PCU) AD/B737/99
Aileron Control Cable Pulley Bracket AD/B737/100
Elevator Feel and Centering Unit AD/B737/101
Flap Control Cable Failure Detection System AD/B737/102
Rudder Power Control Unit Replacement AD/B737/103
Rudder Power Control Unit Inspection AD/B737/104
Rudder Trim Switch AD/B737/105
Aileron Centring Spring and Trim Mechanism AD/B737/106
Aileron and Elevator Power Control Unit Replacement AD/B737/107
Rudder Standby Power Control Unit - Bearing Replacement AD/B737/108
Flying Control Power Control Unit Cylinder Bore Replacement AD/B737/109 Amdt 2
Rudder Yaw Damper Valve Replacement AD/B737/110 Amdt 1
Seat Track Alignment AD/B737/111 Amdt 1
Yaw Damper Coupler Internal Rate Gyroscope AD/B737/112
Rudder Power Control Unit Replacement AD/B737/113
Aileron AD/B737/114 Amdt 1
Horizontal Stabiliser AD/B737/115
Yaw Damper and Rudder Power Control Unit Wiring Change AD/B737/116 Amdt 1
Main Cargo Door AD/B737/117
Standby Hydraulic System - Hydraulic Fuse Operation AD/B737/118
Fuel Boost Pump Wiring AD/B737/119 Amdt 2
Rudder Pedal Pushrods AD/B737/120
Fuel Boost Pump Wiring AD/B737/121 Amdt 1
Fuel Valve Actuator Replacement AD/B737/122
Rudder Control System Component Changes AD/B737/123
Aft Cargo Door Frame and the Cross Beams AD/B737/124 Amdt 2
Centre Wing Fuel Tank Float Switch Wiring AD/B737/125 Amdt 1
Body Station 1088 Bulkhead Terminal Support Fitting Bolts AD/B737/126
Elevator Tab Push Rod Attachment AD/B737/127 Amdt 2
Forward Lavatory Drain - Isolation Valve AD/B737/128
Aft Pressure Bulkhead Web AD/B737/129
Rudder PCU - Displacement Tests AD/B737/130 Amdt 1
Electrical Power AD/B737/131 Amdt 4
Main Landing Gear Tie Bolts AD/B737/132 Amdt 1
Flight Deck Door Upper Decompression Panel AD/B737/133
Argo-Tech/TRW Fuel Boost Pumps AD/B737/134
Refuel Valve Actuator Suppression Diodes AD/B737/135 Amdt 1
Flight Spoiler Control System Inspection AD/B737/136
LE Slat Actuator Rod End AD/B737/137 Amdt 1
Fuel Boost Pump Wiring AD/B737/138
Wire Bundle Chafing - Electric Motor Driven Hydraulic Pump AD/B737/139
Main Landing Gear Axle Flange AD/B737/140
Forward Pressure Bulkhead AD/B737/141
Forward Cargo Door Frame AD/B737/142 Amdt 1
Fuel Low Pressure Switches and Boost Pumps AD/B737/143
Taxi Light Assembly AD/B737/144
Flightcrew Seat Locks and Seat Tracks AD/B737/145 Amdt 1
Oxygen Masks AD/B737/146
Cabin Door Handle Mounting Hub AD/B737/147
Uncommanded Rudder AD/B737/148 Amdt 1
Autothrottle Computer AD/B737/149
Fuel Quantity Indicating System - No. 2 Tank Wiring Harness AD/B737/150
Air Conditioning Duct Insulation AD/B737/151
Centre Fuel Tank - Limitations AD/B737/152
Elevator Tab Control Rod Jam Nut AD/B737/153 Amdt 1
Elevator Tab AD/B737/154 Amdt 2
Elevator Hinge Plates AD/B737/155
Fuel Tank Vent System AD/B737/156
Oxygen Generators AD/B737/157
Fuel System Wiring Shielding and Separation AD/B737/158 Amdt 1
Engine Fuel Shutoff Valve Wiring AD/B737/159
Hydraulic Shutoff Valves AD/B737/160
Main Wheel Well Electrical Connectors AD/B737/161
In-Flight Entertainment System FAA STC ST00171SE AD/B737/162
Passenger Entertainment System FAA STC ST09100AC-D, ST09104AC-D, AD/B737/163
Elevator Tab Repair AD/B737/164 Amdt 1
Aft Pressure Bulkhead-to-Fuselage Attachment AD/B737/165
Escape Slide AD/B737/166
Keel Beam Splices AD/B737/167
Main Wheel Well Junction Box Electrical Wire Chafing AD/B737/168
Aft Pressure Bulkhead BS 1016 and Vertical Fin Forward Attachment Body AD/B737/169
Rudder Pedal Pushrod Fastener AD/B737/170
Elevator Hinge Plates AD/B737/171
Speedbrake Operation Limitation AD/B737/172 Amdt 1
Power Distribution Panels AD/B737/173
Shoulder Restraint of Attendant or Observers Seat AD/B737/174
Elevator Tab - 2 AD/B737/175
Inspection and Replacement of Engine and APU Fire Detection System AD/B737/176
Rudder Pedal Housing AD/B737/177
MLG Support Beam Primary Support Pin AD/B737/178
Fuel Hose Quick Disconnect Coupling - CANCELLED AD/B737/179
Speedbrake Operation Limitation - 2 AD/B737/180 Amdt 1
Flap Track Assembly and Rear Spar Attachments AD/B737/181
Elevator PCU Retention Bracket AD/B737/182
Fuselage Lap Joints AD/B737/183
Fuselage Lap Joint Repairs AD/B737/184
Airframe Limit Cycle Oscillation AD/B737/185 Amdt 1
Aileron Tab Control Rod Barrel AD/B737/186
Captains Pitot Heater AD/B737/187
Main Wheel Well Electrical Connectors AD/B737/188 Amdt 1
Rudder Feel and Centering Unit AD/B737/189
Centre Tank Fuel Pump Limitations - CANCELLED AD/B737/190 Amdt 1
Strut Insulation Blankets AD/B737/191
Elevator Tab Mast Fitting AD/B737/192 Amdt 1
Flight Deck Emergency Windows AD/B737/193
Keel Beam Structure AD/B737/194
Elevator Balance Panel Fasteners AD/B737/195
Elevator Power Control Unit Input Rods AD/B737/196
Flight Control Modules - Replacement AD/B737/197 Amdt 2
Centre Tank Fuel Pumps AD/B737/198
Aileron Transfer Mechanism Lower Bearing Support at First Officer Position AD/B737/199
Outboard Mid-Flap Carriage Spindle AD/B737/200 Amdt 1
Rudder Control System AD/B737/201
Centre Fuel Tank Limitations AD/B737/202
Pressure Fuelling System AD/B737/203
Water Purifier - LBA STC TA0245 - CANCELLED AD/B737/204
Water Purifier - JAA STC LBA.21E2.TA0307 - CANCELLED AD/B737/205
Water Purifier - JAA STC LBA.21E2.TA0501 - CANCELLED AD/B737/206
Fuel Hose Coupling - Inspection AD/B737/207
Oxygen Masks AD/B737/208
Engine Mount - Inspection AD/B737/209
Elevator and Elevator Tab Assembly AD/B737/210
Forward Pressure Bulkhead - 2 AD/B737/211
Landing Gear Parts/Records AD/B737/212
Fuselage Lap Joints AD/B737/213
Fuselage Skin Lap Joint - Fatigue Cracking AD/B737/214
Hydraulic Accumulator End Cap Separation AD/B737/215
Flightcrew Oxygen Masks AD/B737/216
Reinforced Flight Deck Door Decompression Panel AD/B737/217
Windshield Wipers AD/B737/218
Rudder Front Spar Flange Bolts AD/B737/219
Video Distribution Unit Connectors AD/B737/220
Potable Water Pressure Relief Valve AD/B737/221
Forward Door Escape Slide Stowage Compartments AD/B737/222
Door Mounted Escape Slide Latch Block Assembly AD/B737/223 Amdt 1
Horizontal Stabilisers Front and Rear Spar Attachment AD/B737/224 Amdt 1
Proximity Switch Electronics Unit AD/B737/225
Main Fuel Tank Aft Fuel Boost Pump Wiring AD/B737/226
Electrical Bonding AD/B737/227
Honeywell Start Converter Unit AD/B737/228
Forward Lavatory Drain System AD/B737/229
Engine Fire extinguisher Squib Firing Circuit AD/B737/230
Fuselage Upper and Lower Skin Panels AD/B737/231
Horizontal Stabiliser Pivot Hinge Pins AD/B737/232
Cargo Restraint Strap Assemblies AD/B737/233
Pylon Sealing AD/B737/234
Fuselage Skin Area at the Dorsal Fin Assembly AD/B737/235
0
0
0