Airworthiness Directives 2004
I, DAVID ALAN VILLIERS, delegate of the Civil Aviation Safety
Authority, acting under subregulation 39.001 (1) of the Civil
Aviation Safety Regulations 1998:
(a) revoke the Airworthiness Directives mentioned in
Schedule 1; and
(b) make, as separate instruments, each Airworthiness
Directive mentioned in Schedule 1 and attached.
David Villiers
Delegate of the Civil Aviation Safety Authority
20 December 2004
Note: Each attached Airworthiness Directive is being re-made in exactly the
same form as appears in the latest published edition of the Directive.
Schedule 1 Revocation and Remaking of
Airworthiness Directives
Boeing 737 Series Aeroplanes
AD Name AD Number
Cockpit Side Window - F-N Window Post AD/B737/1 Amdt 2
Engine Fuel Supply - Leak Tests AD/B737/2
A.P.U. Generator, Feeder Wire Bundle - Inspection AD/B737/3
Side of Body Rib AD/B737/4 Amdt 1
Wing-To-Body Drag Angle AD/B737/5
Rear Pressure Bulkhead AD/B737/6 Amdt 1
Fuselage Frames Adjacent to Forward Airstair AD/B737/7
Evacuation Slide Compartment Latch Assembly AD/B737/8 Amdt 2
Horizontal Stabilizer - Centre Section Rear Spar AD/B737/9
Aft Lower Cargo Doorway Frame AD/B737/10 Amdt 1
Horizontal Stabilizer Centre Section - Rear Spar Upper Chord Attach Lugs AD/B737/11
Supplemental Structural Inspection Program AD/B737/12
Horizontal Stabilizer Centre Section AD/B737/13
Forward Lower Cargo Doorway Frame AD/B737/14
Fuel Boost Pump Bypass Valve AD/B737/15 Amdt 3
Engine Flameouts - Revised Operating Technique and Modifications AD/B737/16 Amdt 3
Aft Lavatory Dispenser Cavity Liner AD/B737/17
Take-Off Warning AD/B737/18 Amdt 1
Engine Overheat, Fire Detection and Fire Extinguishing Systems AD/B737/19
Engine Fire/Overheat Detection Module AD/B737/20 Amdt 2
Generator Control Unit (GCU) Filter Modules AD/B737/21
APU Fuel Drains AD/B737/22 Amdt 1
Forward Service Doorway Aft Frame AD/B737/23 Amdt 3
Forward Galley Doorway Upper Corners AD/B737/24
Forward Lavatory Drain System - CANCELLED AD/B737/25 Amdt 1
Forward Service Doorway - Aft Frame - CANCELLED AD/B737/26
TE Flap Track Support Fitting Attach Bolts AD/B737/27 Amdt 1
Flight Attendant Seats AD/B737/28 Amdt 1
Window Belt Skin Doubler AD/B737/29 Amdt 1
Engine Throttle Cable AD/B737/30 Amdt 2
Fuselage - Longitudinal Lap Joint Lower Skin at Left and Right Stringer 14 AD/B737/31
Configuration, Maintenance and Procedures Standard for Extended Range AD/B737/32 Amdt 3
Forward and Aft Cargo Compartments AD/B737/33
Forward Left Entry Door Fuselage Aft Frame Bottom Door Stop Fitting Bolts AD/B737/34
Engine Operation in Icing Conditions - CANCELLED AD/B737/35
Cabin Door Blowout Panels AD/B737/36
Fuselage Lap Joints BS259 to BS1016 AD/B737/37
Fuselage Lap Joints BS259 to BS1016 AD/B737/38
APU Fire Detector Element AD/B737/39
Structural Modification Program AD/B737/40
Forward Door Evacuation Slides AD/B737/41
Escape Slide Release Cable AD/B737/42
Nacelle Strut Firewall Seal AD/B737/43 Amdt 1
Fuel Tank Access Doors AD/B737/44
Takeoff Configuration Warning System AD/B737/45 Amdt 1
Engine Fire/Overheat Detection System AD/B737/46
Left Engine Fuel Feed Tube AD/B737/47
Rudder Trim AD/B737/48
Outboard Flaptrack Support Fitting Attach Bolts AD/B737/49
APU - EGT Overtemperature Condition AD/B737/50
Outboard Flap Forward Support Fitting Attach Bolts AD/B737/51
Corrosion Prevention and Control Program AD/B737/52 Amdt 2
Flight Attendant Seats AD/B737/53
Overhead Wire Bundle AD/B737/54 Amdt 1
APU Power Feeder Cable Bundle Chafing AD/B737/55
Engine Control Cable AD/B737/56
MLG Actuator Beam AD/B737/57 Amdt 2
Magnetic Standby Compass Liner AD/B737/58
Engine Fire Extinguishing System AD/B737/59
Crew Call Horn AD/B737/60
Main Deck Cargo Compartment AD/B737/61 Amdt 1
Main Fuel Tank Float Switch Electrical Harness AD/B737/62 Amdt 1
Stabilizer Trim Jackscrew Actuator AD/B737/63
Forward Door Escape Slide AD/B737/64 Amdt 1
Radio Control Panels AD/B737/65
Electrical Wiring Loom AD/B737/66 Amdt 1
Electrical Power Distribution P6 Load Control Centre Panel AD/B737/67
Sperry SP300 Autopilot Mode Control Panel AD/B737/68
Transro Single Flight Attendant Seat Pan AD/B737/69
Thrust Reverser - Auxiliary Slider Track Liner AD/B737/70
Brake Wear Limit AD/B737/71
Side of Body Floor Panel Inserts AD/B737/72
Cabin Overhead Stowage Bins AD/B737/73
Thrust Reverser Actuator Piston Seal AD/B737/74
Passenger Oxygen System AD/B737/75
Flight Control Cable Guards AD/B737/76
Pilot and Co-Pilot Seats AD/B737/77 Amdt 1
Evacuation Slide Valise AD/B737/78
Main Rudder Power Control Unit (PCU) AD/B737/79
Wing Leading Edge Panel AD/B737/80 Amdt 1
Thrust Reverser Control System Inspection and Modification AD/B737/81 Amdt 1
Thrust Reverser Sync-Lock System Test AD/B737/82 Amdt 2
Fuselage - Upper Deck Cargo Door - CANCELLED AD/B737/83
Main Rudder Power Control Unit (PCU) AD/B737/84
Fuel Actuator Shutoff Valve AD/B737/85
Body Station 344 to 360 Support Structure AD/B737/86
Fuselage Lap Joints, Lower Skins AD/B737/87 Amdt 2
Horizontal Stabiliser Trim Electric Actuator AD/B737/88
Main Deck Cargo Door - Existing Frame to Lower Sill Tie-Down AD/B737/89
Main Deck Cargo Door AD/B737/90 Amdt 2
Main Deck Cargo Door Hinge, Shim and Fairing AD/B737/91
Thrust Reverser Fan Cowl Firewall AD/B737/92
Galley Feeder Wiring AD/B737/93
Outboard Chords of BS 727 Frame and Stringer 18A AD/B737/94
Electrical/Electronics Equipment Bay Wire Chafing AD/B737/95
Fin Aft Terminal Support Fitting Bolts - CANCELLED AD/B737/96
Fwd Galley Service Door Lower Gate Hinge AD/B737/97
Krueger Flap Actuator Support Fitting AD/B737/98
Main Rudder Power Control Unit (PCU) AD/B737/99
Aileron Control Cable Pulley Bracket AD/B737/100
Elevator Feel and Centering Unit AD/B737/101
Flap Control Cable Failure Detection System AD/B737/102
Rudder Power Control Unit Replacement AD/B737/103
Rudder Power Control Unit Inspection AD/B737/104
Rudder Trim Switch AD/B737/105
Aileron Centring Spring and Trim Mechanism AD/B737/106
Aileron and Elevator Power Control Unit Replacement AD/B737/107
Rudder Standby Power Control Unit - Bearing Replacement AD/B737/108
Flying Control Power Control Unit Cylinder Bore Replacement AD/B737/109 Amdt 2
Rudder Yaw Damper Valve Replacement AD/B737/110 Amdt 1
Seat Track Alignment AD/B737/111 Amdt 1
Yaw Damper Coupler Internal Rate Gyroscope AD/B737/112
Rudder Power Control Unit Replacement AD/B737/113
Aileron AD/B737/114 Amdt 1
Horizontal Stabiliser AD/B737/115
Yaw Damper and Rudder Power Control Unit Wiring Change AD/B737/116 Amdt 1
Main Cargo Door AD/B737/117
Standby Hydraulic System - Hydraulic Fuse Operation AD/B737/118
Fuel Boost Pump Wiring AD/B737/119 Amdt 2
Rudder Pedal Pushrods AD/B737/120
Fuel Boost Pump Wiring AD/B737/121 Amdt 1
Fuel Valve Actuator Replacement AD/B737/122
Rudder Control System Component Changes AD/B737/123
Aft Cargo Door Frame and the Cross Beams AD/B737/124 Amdt 2
Centre Wing Fuel Tank Float Switch Wiring AD/B737/125 Amdt 1
Body Station 1088 Bulkhead Terminal Support Fitting Bolts AD/B737/126
Elevator Tab Push Rod Attachment AD/B737/127 Amdt 2
Forward Lavatory Drain - Isolation Valve AD/B737/128
Aft Pressure Bulkhead Web AD/B737/129
Rudder PCU - Displacement Tests AD/B737/130 Amdt 1
Electrical Power AD/B737/131 Amdt 4
Main Landing Gear Tie Bolts AD/B737/132 Amdt 1
Flight Deck Door Upper Decompression Panel AD/B737/133
Argo-Tech/TRW Fuel Boost Pumps AD/B737/134
Refuel Valve Actuator Suppression Diodes AD/B737/135 Amdt 1
Flight Spoiler Control System Inspection AD/B737/136
LE Slat Actuator Rod End AD/B737/137 Amdt 1
Fuel Boost Pump Wiring AD/B737/138
Wire Bundle Chafing - Electric Motor Driven Hydraulic Pump AD/B737/139
Main Landing Gear Axle Flange AD/B737/140
Forward Pressure Bulkhead AD/B737/141
Forward Cargo Door Frame AD/B737/142 Amdt 1
Fuel Low Pressure Switches and Boost Pumps AD/B737/143
Taxi Light Assembly AD/B737/144
Flightcrew Seat Locks and Seat Tracks AD/B737/145 Amdt 1
Oxygen Masks AD/B737/146
Cabin Door Handle Mounting Hub AD/B737/147
Uncommanded Rudder AD/B737/148 Amdt 1
Autothrottle Computer AD/B737/149
Fuel Quantity Indicating System - No. 2 Tank Wiring Harness AD/B737/150
Air Conditioning Duct Insulation AD/B737/151
Centre Fuel Tank - Limitations AD/B737/152
Elevator Tab Control Rod Jam Nut AD/B737/153 Amdt 1
Elevator Tab AD/B737/154 Amdt 2
Elevator Hinge Plates AD/B737/155
Fuel Tank Vent System AD/B737/156
Oxygen Generators AD/B737/157
Fuel System Wiring Shielding and Separation AD/B737/158 Amdt 1
Engine Fuel Shutoff Valve Wiring AD/B737/159
Hydraulic Shutoff Valves AD/B737/160
Main Wheel Well Electrical Connectors AD/B737/161
In-Flight Entertainment System FAA STC ST00171SE AD/B737/162
Passenger Entertainment System FAA STC ST09100AC-D, ST09104AC-D, AD/B737/163
Elevator Tab Repair AD/B737/164 Amdt 1
Aft Pressure Bulkhead-to-Fuselage Attachment AD/B737/165
Escape Slide AD/B737/166
Keel Beam Splices AD/B737/167
Main Wheel Well Junction Box Electrical Wire Chafing AD/B737/168
Aft Pressure Bulkhead BS 1016 and Vertical Fin Forward Attachment Body AD/B737/169
Rudder Pedal Pushrod Fastener AD/B737/170
Elevator Hinge Plates AD/B737/171
Speedbrake Operation Limitation AD/B737/172 Amdt 1
Power Distribution Panels AD/B737/173
Shoulder Restraint of Attendant or Observers Seat AD/B737/174
Elevator Tab - 2 AD/B737/175
Inspection and Replacement of Engine and APU Fire Detection System AD/B737/176
Rudder Pedal Housing AD/B737/177
MLG Support Beam Primary Support Pin AD/B737/178
Fuel Hose Quick Disconnect Coupling - CANCELLED AD/B737/179
Speedbrake Operation Limitation - 2 AD/B737/180 Amdt 1
Flap Track Assembly and Rear Spar Attachments AD/B737/181
Elevator PCU Retention Bracket AD/B737/182
Fuselage Lap Joints AD/B737/183
Fuselage Lap Joint Repairs AD/B737/184
Airframe Limit Cycle Oscillation AD/B737/185 Amdt 1
Aileron Tab Control Rod Barrel AD/B737/186
Captains Pitot Heater AD/B737/187
Main Wheel Well Electrical Connectors AD/B737/188 Amdt 1
Rudder Feel and Centering Unit AD/B737/189
Centre Tank Fuel Pump Limitations - CANCELLED AD/B737/190 Amdt 1
Strut Insulation Blankets AD/B737/191
Elevator Tab Mast Fitting AD/B737/192 Amdt 1
Flight Deck Emergency Windows AD/B737/193
Keel Beam Structure AD/B737/194
Elevator Balance Panel Fasteners AD/B737/195
Elevator Power Control Unit Input Rods AD/B737/196
Flight Control Modules - Replacement AD/B737/197 Amdt 2
Centre Tank Fuel Pumps AD/B737/198
Aileron Transfer Mechanism Lower Bearing Support at First Officer Position AD/B737/199
Outboard Mid-Flap Carriage Spindle AD/B737/200 Amdt 1
Rudder Control System AD/B737/201
Centre Fuel Tank Limitations AD/B737/202
Pressure Fuelling System AD/B737/203
Water Purifier - LBA STC TA0245 - CANCELLED AD/B737/204
Water Purifier - JAA STC LBA.21E2.TA0307 - CANCELLED AD/B737/205
Water Purifier - JAA STC LBA.21E2.TA0501 - CANCELLED AD/B737/206
Fuel Hose Coupling - Inspection AD/B737/207
Oxygen Masks AD/B737/208
Engine Mount - Inspection AD/B737/209
Elevator and Elevator Tab Assembly AD/B737/210
Forward Pressure Bulkhead - 2 AD/B737/211
Landing Gear Parts/Records AD/B737/212
Fuselage Lap Joints AD/B737/213
Fuselage Skin Lap Joint - Fatigue Cracking AD/B737/214
Hydraulic Accumulator End Cap Separation AD/B737/215
Flightcrew Oxygen Masks AD/B737/216
Reinforced Flight Deck Door Decompression Panel AD/B737/217
Windshield Wipers AD/B737/218
Rudder Front Spar Flange Bolts AD/B737/219
Video Distribution Unit Connectors AD/B737/220
Potable Water Pressure Relief Valve AD/B737/221
Forward Door Escape Slide Stowage Compartments AD/B737/222
Door Mounted Escape Slide Latch Block Assembly AD/B737/223 Amdt 1
Horizontal Stabilisers Front and Rear Spar Attachment AD/B737/224 Amdt 1
Proximity Switch Electronics Unit AD/B737/225
Main Fuel Tank Aft Fuel Boost Pump Wiring AD/B737/226
Electrical Bonding AD/B737/227
Honeywell Start Converter Unit AD/B737/228
Forward Lavatory Drain System AD/B737/229
Engine Fire extinguisher Squib Firing Circuit AD/B737/230
Fuselage Upper and Lower Skin Panels AD/B737/231
Horizontal Stabiliser Pivot Hinge Pins AD/B737/232
Cargo Restraint Strap Assemblies AD/B737/233
Pylon Sealing AD/B737/234
Fuselage Skin Area at the Dorsal Fin Assembly AD/B737/235